Yanmar 4JH45 Specifications Page 53
- Page / 126
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
ENGINE OPERATION
JH Series Operation Manual 47
12/05
NOTICE
• If the ambient temperature is below
-16°C (+5°F), rubber components such
as gaskets and seals will harden causing
premature engine wear and damage.
• Consult your authorized Yanmar Marine
engine dealer or distributor if the engine
will be operated outside of this standard
temperature range.
Never engage the starter motor while the
engine is running. Damage to the starter
motor pinion and/or ring gear will result.
STARTING THE ENGINE
1. Open the seacock (if equipped).
2. Open the fuel tank cock.
3. Put remote control handle in
NEUTRAL.
Note: Safety equipment should make it
impossible to start the engine in
any other position than
NEUTRAL.
Figure 1
Figure 1
4. Turn on the battery switch for engine
and engine control unit.
Do not turn off the battery switch during
engine operation. Also, turn it off when
the engine does not operate.
5. If all alarm lamps operate when you
turn on the power switch on the
instrument panel, the warning devices
operate correctly.
6. Pushing the start switch turns on the
engine. Release the switch after the
engine starts.
Start switch
Power switch
042590-01EN00
4JH45_4JH57_4JH80_4JH110_EN_OPM.book 47 ページ ２０１３年１０月８日 火曜日 午後３時５８分
- MARINE ENGINES 1
- 4JH45, 4JH57, 4JH80, 4JH110 2
- TABLE OF 3
- CONTENTS 3
- TABLE OF CONTENTS 4
- INTRODUCTION 7
- RECORD OF OWNERSHIP 8
- JH Series Operation Manual 3 9
- 9
- SAFETY PRECAUTIONS 10
- JH Series Operation Manual 5 11
- Poor Lighting Hazard 12
- Too l Haza rd 12
- Flying Object Hazard 12
- Coolant Hazard 12
- JH Series Operation Manual 7 13
- LOCATION OF SAFETY DECALS 14
- JH Series Operation Manual 9 15
- 10 JH Series Operation Manual 16
- PRODUCT OVERVIEW 17
- New Engine Break-In 18
- COMPONENT IDENTIFICATION 19
- Right Side (Viewed from 20
- Flywheel) - 4JH80/4JH110 20
- - 4JH80/4JH110 20
- NAMEPLATES 21
- FUNCTION OF MAJOR COMPONENTS 22
- ELECTRONIC CONTROL 23
- FEATURES 24
- CONTROL EQUIPMENT 25
- Instrument Panel 27
- Imperial Metric 30
- ScrollScroll 32
- These parameters are 33
- F1A - 3 AMP Fuse 35
- ACC Output 35
- Single-Lever Remote Control 36
- BEFORE YOU OPERATE 37
- DIESEL FUEL 38
- Filling the Fuel Tank 41
- Bleeding the Fuel System 42
- ENGINE OIL 43
- Engine Oil Viscosity 44
- Checking the Engine Oil 44
- MARINE GEAR OR SAIL 45
- DRIVE OIL 45
- Checking Marine Gear Oil 46
- Adding Marine Gear Oil 46
- ENGINE COOLANT 47
- 056989-00X00 48
- ENGINE OPERATION 51
- Start switch 53
- Power switch 53
- If the Engine Fails to Start 54
- Starting at Low Temperatures 54
- REMOTE CONTROL 55
- HANDLE OPERATION 55
- Switching to Trolling (KMH4A 56
- CAUTIONS DURING 57
- OPERATION 57
- Stop switch 58
- Emergency Shutdown 59
- CHECKING THE ENGINE 60
- AFTER OPERATION 60
- PERIODIC 61
- MAINTENANCE 61
- PERIODIC MAINTENANCE 62
- PRECAUTIONS 63
- Tightening Fasteners 64
- PERIODIC MAINTENANCE SCHEDULE 66
- PROCEDURES 68
- After Initial 50 Hours of 69
- Operation 69
- Every 50 Hours of Operation 75
- UPPER LEVEL 77
- LOWER LEVEL 77
- 0004566 77
- Every 500 Hours of Operation 83
- Every 1000 Hours of Operation 84
- 80 JH Series Operation Manual 86
- TROUBLESHOOTING 87
- INFORMATION 88
- TROUBLESHOOTING CHART 89
- DRAIN SEAWATER 98
- COOLING SYSTEM 98
- RETURNING THE ENGINE 99
- TO SERVICE 99
- LONG-TERM STORAGE 100
- 94 JH Series Operation Manual 100
- JH Series Operation Manual 95 101
- SPECIFICATIONS 101
- 4JH45 Engine 102
- 4JH57 Engine 103
- 4JH80 Engine 105
- 4JH110 Engine 106
- SYSTEM DIAGRAMS 109
- WIRING DIAGRAMS 123
- Figure 7 124
- 057149-00EN00 125
Related products and manuals for Engine Yanmar 4JH45
Engine Yanmar BY series Installation Manual
(28 pages)
(28 pages)
Engine Yanmar 3GM30F Specifications
(10 pages)
(10 pages)
Engine Yanmar 6CXM-GTE2 Service Manual
(132 pages)
(132 pages)
Engine Yanmar 3JH4E Service Manual
(214 pages)
(214 pages)
Engine Yanmar 3JH2 Series User Manual
(308 pages)
(308 pages)
Engine Yanmar 1GM10C Specifications
(86 pages)
(86 pages)
Engine Yanmar BY series Installation Manual
(33 pages)
(33 pages)
Engine Yanmar 6CXM-GTE2 Specifications
(50 pages)
(50 pages)
Engine Yanmar MP series Service Manual
(104 pages)
(104 pages)
Engine Yanmar 6BY3-260Z Specifications
(96 pages)
(96 pages)
Engine Yanmar 2GM20C Specifications
(65 pages)
(65 pages)
Engine Yanmar 4BY3-180Z Specifications
(88 pages)
(88 pages)
Engine Yanmar 6LPA-STZP2 Specifications
(106 pages)
(106 pages)
Engine Yanmar 3HM User Manual
(56 pages)
(56 pages)
Engine Yanmar 4JH2E Specifications
(42 pages)
(42 pages)
Engine Yanmar 6BY3-260Z Service Manual
(32 pages)
(32 pages)
Engine Yanmar 2YM15 Service Manual
(231 pages)
(231 pages)
Engine Yanmar 2GM20F User Manual
(69 pages)
Engine Yanmar 3YM30E Specifications
(56 pages)
(56 pages)
Engine Yanmar 6LYA-STP Specifications
(647 pages)
(647 pages)
© 2020, manymanuals.com. All rights reserved. | 0.418 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals